中空玻璃设备清洗机是现代玻璃加工企业的必备机器，卧式的中空玻璃加工设备采用水平卧式结构，平板玻璃放置在传送辊上，经过进料段、清洗段、干燥段、到达出料段，从而制作出中空玻璃。设备的使用必然非常重要，但是昌盛小编认为，清洗机的维护保养工作同样要引起大家重视。

　　Hollow glass equipment cleaning machine is an essential machine for modern glass processing enterprises. The horizontal hollow glass processing equipment adopts a horizontal structure, and the flat glass is placed on the conveyor roller, passing through the feeding section, cleaning section, drying section, and reaching the discharge section to produce hollow glass. The use of equipment is inevitably very important, but the Changsheng editor believes that the maintenance and upkeep of cleaning machines should also be taken seriously.

　　对中空玻璃设备进行日常维护及保养是非常重要的事情，平时要经常观察设备的运动部分、水路系统、风路系统、电气系统，遇有紧急情况立即停车检查。

　　Daily maintenance and upkeep of insulated glass equipment is very important. It is necessary to regularly observe the moving parts, water system, air system, and electrical system of the equipment. In case of emergency, stop the vehicle immediately for inspection.

　　1、运动部分

　　1. Sports section

　　（1）轴承及润滑轴承是在机械传动过程中起固定和减小载荷摩擦系数的部件。也可以说，当其它机件在轴上彼此产生相对运动时，用来降低动力传递过程中的摩擦系数和保持轴中心位置固定的机件。大家要对中空玻璃加工设备的各个润滑点及时进行润滑。

　　(1) Bearings and lubricated bearings are components that fix and reduce the friction coefficient of loads in mechanical transmission processes. It can also be said that when other components generate relative motion on the shaft, it is used to reduce the friction coefficient during power transmission and maintain the fixed position of the shaft center. Everyone should lubricate the various lubrication points of the insulated glass processing equipment in a timely manner.

　　（2）水路系统的维护中空玻璃加工设备清洗段所用水是循环时用的。每天应更换水箱中的存水，以保证清洗用水的干净，每月清洗一次水箱及过滤装置。通过清洗段盖上的观察孔可监视喷水情况，如果发现有堵塞现象，则停泵打开箱盖，拆下喷水嘴，疏通清洗过后安装。（3）分路系统的维护定期检查中空玻璃加工设备的鼓风机运行情况，遇有异常声音时立即停机，报告维修部门检查。每二个月将进风口的过滤栅进行清洗，平时要保持鼓风机房的清洁，以免灰尘被吸入风路，污染玻璃。

　　(2) The water used for cleaning the hollow glass processing equipment in the maintenance of the waterway system is for circulation. The stored water in the water tank should be replaced daily to ensure the cleanliness of the cleaning water. The water tank and filtration device should be cleaned once a month. By cleaning the observation hole on the section cover, the water spray situation can be monitored. If any blockage is found, stop the pump, open the box cover, remove the water spray nozzle, clear and clean it before installation. (3) Regularly check the operation of the blower in the hollow glass processing equipment for the maintenance of the branching system. If there is any abnormal sound, immediately stop the machine and report to the maintenance department for inspection. Clean the filter grille of the air inlet every two months, and keep the blower room clean to prevent dust from being sucked into the air duct and contaminating the glass.

　　2、水路系统中空玻璃加工设备的水路系统由两只水箱四套循环水系统组成。洗涤剂箱宜用PH=7的中性玻璃清洗剂，最后一道玻璃漂洗宜用去离子水，水的质量直接影响后玻璃的表面清洁度。洗涤液的温度一般控制在30～60度（水温加热控制装置用户自备）。

　　2. The water system of the hollow glass processing equipment in the water system consists of two water tanks and four sets of circulating water systems. Neutral glass cleaner with pH=7 should be used for the detergent box, and deionized water should be used for the final glass rinse. The quality of water directly affects the surface cleanliness of the glass. The temperature of the washing solution is generally controlled between 30-60 degrees Celsius (the water temperature heating control device should be provided by the user).

　　3、风路系统鼓风机出来的压缩空气经分风器分别送给上、下冷风刀及上、下热风刀与玻璃平面之间的距离可以调整，变动玻璃厚度时，一定要注意调整此间隙。

　　3. The compressed air from the blower of the air duct system is sent to the upper and lower cold air knives and the distance between the upper and lower hot air knives and the glass plane can be adjusted. When changing the thickness of the glass, be sure to adjust this gap.

　　综上所述，大家维护保养中空玻璃设备主要是对设备的运动、水路、风路系统方面，只要大家细心操作，注意中空玻璃加工的各个细节，肯定能够制作出高质量的中空玻璃。

　　In summary, the maintenance of insulated glass equipment mainly focuses on the movement, water and air systems of the equipment. As long as everyone operates carefully and pays attention to the details of insulated glass processing, high-quality insulated glass can definitely be produced.

　　本文由 中空玻璃设备清洗机  友情奉献.更多有关的知识请点击  http://www.jncsjx.com/   真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from the hollow glass equipment cleaning machine For more related knowledge, please click http://www.jncsjx.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.