我们在结束每日的生产活动后为了降低中空玻璃双组份打胶机故障率提供生产我们必须做到以下几点

　　Following the end of the daily production activities, in order to reduce the failure rate of the hollow glass double component breaker, we must do the following

　　1、双组份打胶机每次使用完毕，要将机器上的残胶及灰尘清除干净，使机器保持清洁。

　　1, two sets of glue machine, after each use, the machine will be residual glue and dust clean, make the machine keep clean.

　　2、不定期的应全面检查各紧固件是否有松动现象，并重新紧固。建议每个三天进行一次排查!

　　2, irregular, should be fully checked whether the fasteners are loose, and re tightened. It is recommended to have an investigation every three days!

　　3、清理混胶器及其前后管道内的凝结胶，定期清理止回阀;发现阻力增高或者堵塞现象，要及时清理。

　　3, cleaning glue mixer and its pipe before and after the coagulation gel, regular cleaning check valve; found resistance increased or blocked phenomenon, should promptly clean up.

　　2、定期检查电气接线是否有松动及接地可靠性。

　　2 、 regularly check whether the electrical wiring is loose and the reliability of the grounding.

　　其实不单单是中空玻璃双组份打胶机我们身边的其他设备也同样需要定期的维护保养，设备其实同我们人一样，你只要真心的、认真的对待他呵护她，设备也会尽心尽力的为您做付出大的力量来给你带来大的收益。

　　In fact, not only is the other equipment of hollow glass two-component glue machine around us also need regular maintenance equipment, in fact we like people, as long as you treat him, care for her, the equipment will also dedicated for you do pay a maximum power to benefit you.

　　3、要有足够的压力。同时，连接管路时要注意不可超过接头牙面并消除管接内的各种金属微尘类污垢。

　　3, there should be enough pressure. At the same time, pay attention not to exceed the joint tooth surface when connecting the pipeline, and eliminate all kinds of metal dust like dirt in the pipe connection.

　　平时在维护保养的时候只要做到连接管路的清洁以及注意接头是否完好规矩即可。

　　Usually in maintenance, as long as the connection pipe cleaning, and pay attention to whether the joints are intact, rules can.

　　4、修理时要打开电磁阀的阀芯，并且要注意更换密封圈，同时要要在每次清理过后加入少量润滑油后再装入。

　　4, repair the solenoid valve to open the valve, and pay attention to the replacement of sealing ring, and at the same time after each cleaning, add a small amount of lubricating oil and then loaded.

　　反之如果你没有对设备进行认真的呵护维护他同样会以各种方式来表达不满，比如设备故障罢工!

　　On the other hand, if you do not take care of the equipment seriously, he will also express his dissatisfaction in various ways, such as equipment failure and strike!

　　本文由双组份打胶机为您提供，我们的网站是:http://linshi.jncsjx.com/我们将以全心全意的热情为您提供更优质的服务，欢迎您的访问!

　　This article is made up of a two component press machine. Our website is: http://linshi.jncsjx.com/, we will provide you with better service with your wholehearted enthusiasm, and welcome your visit!